 |
Recharging the AC System Posted by: DiscountACparts
Video duration: 69 seconds http://www.discounta cparts.com/air_condi tioning_learning.htm When recharging the ac system use a charging scale to put the correct amount of refrigerant back into the system. With the system at a partial charge close the high side and start the vehicle. After starting the vehicle and running it with the compressor off check the serpentine belt to make sure it was installed correctly. |
 |
Evacuating the AC System Posted by: DiscountACparts
Video duration: 43 seconds http://www.discounta cparts.com/car_air_c onditioning.htm Evacuating the ac system should be done with both of the couplers installed and both of the valves completely open. The low side gauge should start to draw a vacuum. You should leave the vacuum on for 30 minutes to an hour. After you pull the vacuum on the system it's ready to be recharged. |
 |
Orifice Tube Installation Posted by: DiscountACparts
Video duration: 26 seconds http://www.discounta cparts.com/a-c-expan sion-device/ The orifice tube should have an arrow which points to the flow of the refrigerant. Make sure you're installing the orifice tube the right way. The installation is made easier by getting the o-rings wet with oil. |
 |
Air Conditiioning Compressor : Install Posted by: DiscountACparts
Video duration: 57 seconds http://www.discounta cparts.com/air_condi tioning_compressor.h tm Air conditioning compressor installation is properly done after the system has been flushed. First put the hose manifold back on. Bolt the compressor to the mounts. Cycle the ac compressor by spinning the clutch plate several times. Install the compressor clutch wire, and install the serpentine belt. |
 |
AC Flush Posted by: DiscountACparts
Video duration: 25 seconds http://www.discounta cparts.com/auto_air_ conditioning_compres sor.htm Flush your ac system before installing a new ac compressor. Metal shavings or other debris from the defective compressor will contaminate the ac system. Shoot the fluid in one side of the compressor hose fittings to flush the system. Using shop air, push the fluid through the entire system and out the other port. |
 |
AC Compressor Oil Posted by: DiscountACparts
Video duration: 70 seconds http://www.discounta cparts.com/car_air_c onditioning.htm When adding ac compressor oil you should empty all of the oil used in shipping first. The correct amount of ac compressor oil to be added is usually stamped on the compressor. The manufacturer recommends a specific amount of oil for an ac compressor. |
 |
AC Drier and Orifice Tube Posted by: DiscountACparts
Video duration: 112 seconds http://www.discounta cparts.com/a-c-accum ulator-drier/ When you remove the ac drier and orifice tube you want to be very careful not to get any debris inside any of the hoses. Always use a backup wrench when removing any of the lines. Check for any excess metal shavings. Excess metal shavings are an indication that the entire ac system needs to be flushed. |
 |
AC Compressor : Removing your AC Compressor Posted by: DiscountACparts
Video duration: 55 seconds http://www.discounta cparts.com/a-c-compr essor/ An ac compressor should be removed one step at a time. When removing your ac compressor you should remove the clutch wire and hose assemblies. Remove the ac compressor manifold bolts. Be careful not to get any dirt or debris in the hoses. |
 |
How to Temperature Test Auto AC System - DiscountACParts.com Posted by: DiscountACparts
Video duration: 390 seconds http://www.discounta cparts.com/car_air_c onditioning.htm?sour ce=ytactemptest07 Post auto ac compressor install procedure. How to perform a proper temperature test on your car air conditioning system. Step by step guide on checking temperature and performing post installation temperature test on a vehicle's a/c system. |
 |
How To Auto AC System Cleaning - DiscountACparts.com Posted by: DiscountACparts
Video duration: 409 seconds http://www.discounta cparts.com/air_condi tioning_compressor.h tm?source=ytautoaccl eaning07 How to clean your car's air conditioning a/c system. Important tutorial on auto ac cleaning. Car ac systems need to be cleaned thoroughly before changing the ac compressor. Here is an instructional video for home 'do it yourself' auto mechanic (s) and professional mechanic (s). |
 |
How to Install Auto Car AC Compressor - DiscountACparts.com Posted by: DiscountACparts
Video duration: 545 seconds http://www.discounta cparts.com/air_condi tioning_compressor.h tm?source=ytreplacea ccompressor07 Valuable instructions on replacing your car's AC Compressor - For professional mechanics and do it yourself-ers. AC Compressor replacement is an easy job to mess up. Here is a helpful start. Visit DiscountACparts.com for more information and the largest inventory of auto AC parts. |
